氧化铝表面丝印油墨

氧化铝表面丝印油墨

适用於各种金属、玻璃、陶瓷、石材、电镀(含水电镀)、阳极氧化铝表面、静电喷漆面及烤漆面等制品的丝印及移印，不需加固化剂，不需烘烤，即可获得优异的附着力。油墨特性：1、平光(如需亮光请选择我司JL系列)、附着力佳、耐酒精、耐化学品；2、手感好，流平性佳、面光洁；3、表面硬度好，耐冲击性能强、抗刮伤；4、耐酒精、耐化学品程度佳；印刷：选用网目为100-420目，以120T聚酯单丝、感光胶网版计算涂覆盖面积每公斤达35~40㎡。表干时间自然挥发5-10分钟，实干时间在24小时以内，48小时後达优秀性能。1.用B-03**稀释剂开油水2.用718洗网水洗网。3.可选择添加JS-9硬化剂10%用於增加油墨附着力及物理化学抗性。4.烤箱80℃烘烤30分钟佳能更优。测试方法(完全干燥後)：1.3M胶纸粘在画有百格的油墨表面45度角迅速拉起不脱油。2.纯度99%的酒精500G力在油墨表面来回擦拭200次无脱色。使用方法：1.使用前应充分搅拌，用後随时密封。2.搅拌时先加固化剂静置10分钟後，再加稀释剂10-15%，稀释到印刷粘度。3. 加入固化剂的油墨使用时限为4-6小时，过期请弃用，剩余油墨不可回收。One c o mponent of alumina ink
Applicable for all kinds of metal, glass, ceramics, stone, electroplating (aqueous electroplating), anodic alumina surface, electrostatic painting surface and face painting and other products and silk screen printing, without curing agent, and does not need to bake, can obtain excellent adhesion. Ink characteristics: 1, Plano (for light please choose our JL Series), good adhesion, resistance to alcohol, resistant to chemicals; 2, good hand feeling, good leveling, smooth surface; 3, good surface hardness, strong shock resistance, anti scratch; 4, alcohol resistant, chemical resistant degree is good; printing: choice of mesh for 100-420 orders, in 120t polyester monofilament, photosensitive adhesive screen calculation coated area coverage per kilogram of 35-40 square meters. Table dry time natural volatile 5-10 minutes, hard work time within 24 hours, 48 hours after the outstanding performance. 1 use B-03 special diluent open oil water 718 with 2 wash n e t. 3 can choose JS-9 10% add hardening agent used to increase the ink adhesion and physical and chemical resistance. 4 oven 80 degrees bake 30 minutes Canon better. Test method (c o mpletely dry):1.3M gummed paper tape‘s ink surface 45 degree angle quickly pulled off the oil painting. 2 purity of 99% alcohol 500G force on the surface of the ink back and forth 200 times without decolorization. Usage: 1 before use should be fully stirred, sealed at any time after use. 2 stirring, adding the curing agent for 10 minutes, then add the diluent 10-15%, diluted to printing viscosity. 3 add hardener inks use time is 4-6 hours, please not expired, the remaining ink Unrecyclable.